粉體行業在線展覽
粉體行業在線展覽
XSG系列
直接聯系
四川川大干燥科技工程有限責任公司.
四川成都
面議
XSG系列
5551
| 簡介： |
|
工作原理 WORKING PRINCIPLE：
熱空氣由入口管以適宜的噴動速度從干燥機底部進入攪拌粉碎干燥室，對物料產生強烈的剪切、吹浮、旋轉作用，于是物料受到離心、剪切、碰撞、摩擦而被微?；瑥娀藗髻|傳熱。在干燥機底部，較大較濕的顆粒團在攪拌器的作用下被機械破碎，濕含量較低，顆粒度較小的顆粒被旋轉氣流夾帶上升，在上升過程中進一步干燥。由于氣固兩相作旋轉流動，固相慣性大于氣相，固氣兩相間的相對速度較大，強化兩相間的傳質傳熱，所以該機生產強度高。
Hot air enters into stirring and crushing and drying chamber from the botton of drier with suitable atomizing speed. It exerts strong shearing, blowing, floating and rotating effect to raw material. Therelore raw material is granulated through centrifuge, sheafing, impacting and friction effect. It strengthens the process of heat exchange. At the bottom of drier, the large and damp granule is crushed under the action of stirrer and the granule that is small in particle and contain less moisture will lift accompanied with revolving air stream. During the period of lift, it is dried further. Because two phases gas and solid of flow in rotating and the inertia of solid phase is more than that of gas and the relative velocity between solid and gas phases is large, so it strengthens the process of heat exchange. Therefore the machine has strong drying capacity.
產品特點 PRODUCT FEATURES:
由于物料受到離心、剪切、碰撞、摩擦而被微粒化，呈高度分散狀態及固氣兩相間的相對速度較大，強化了傳質傳熱，使該機生產強度高。
干燥氣體進入干燥機底部，產生強烈的旋轉氣流，對器壁上物料產生強烈的沖刷帶出作用，消除粘壁現象。 在干燥機底部高溫區，熱敏性物料不與熱表面直接接觸，并裝有特殊裝置，解決了熱敏性物料的焦化變色問題。 由于干燥室內周向氣速高，物料停留時間短，達到高效、快速、小設備、大生產。 干燥室上部加裝陶析環及旋流片可以控制出口物料的粒度及濕度，以達到不同物料的終水份粒度的要求。 Because the raw material particulate exists in high dispersing state caused by centrifuge, shearing, impacting and rubbing effect. Moreover the relative velocity between solid and gas phases is high, so it strengthens the process of heat exchange. Therefore the machine has strong drying capacity.
Dry gas enters into the bottom of drier and produces strong rotating air stream that exerts strong rushing effect to raw material on the wall, therefore the phenomenon of stricking on the wall is removed.
At the bottom of drier, where is high temperature area, heatsensitivity raw material can not contact with heat surface directly, therefore it solves the carbonization and color charge problems of heat sensitivity raw material.
Because gas speed at circle inside the drying chamber is high and the staying time of raw material is short, high efficiency and quick speed can be realized. It is possible for small equipment to carry out large-scale production.
There are rotation flow pieces and elutriation ring inside the drying charnber. It is used to control the moisture and granule of raw material to the needed level.
應用范圍 SCOPE OF APPLICATION：
有機物：阿特拉津（農藥殺蟲劑）、月桂酸隔、苯甲酸、安息香酸、殺菌丹、草酸鈉、醋酸纖維素等。
染料：蒽醌、黑色氧化鐵、靛蘭顏料、丁酸、氫氧化鈦、硫化鋅、各種偶氮染料中間體。 無機物：硼砂、碳酸鈣、氫氯化物、硫酸銅、氧化鐵、碳酸鋇、三氧化銻、各種金屬氫氧化物、各種重金屬鹽、合成冰晶石等。 陶瓷：高嶺土、三氧化硅、粘土等。 食品：大豆蛋白、膠凝淀粉、酒糟、小麥糖、小麥淀粉等。
技術參數 TECHNICAL PARAMETERS：
|
